Posted on

Learning How NOT to Repurpose a Shutter – Functional Rustic Approach

I am well on my way to learning 10,000 ways not to turn a shutter into a chalk board!

I have not failed..jpg

My inclination is to dwell on this or give up. I salvaged a bunch of plastic shutters and have high hopes of what I can repurpose them into. Making them into rustic chalk boards is on the top of my list.

Plastic Shutter
Plastic Shutter

I had some success when I first started the project. From afar the piece looked great. The blue of the shutter was quaint, the white popped and drew in your attention and the black board was distinctive and functional. But, looking good from afar is not the same as looking good.

Shutter Chalk Board Organizer
Salvaged Shutter Chalkboard Organizer.

The picture above is after two coats of white deck stain and two or three coats of chalkboard paint. All of the painting was done free hand so the lines were not at all straight. That is the “from afar” part that looks good. From across the room it is stunning but, when you get close, my skills as a novice are evident.

I am well aware that I am not a professional painter. I’m proud of what I created though. However, I made ‘mistakes’ and I am learning from them. My free hand painting attempt did not provide the clean lines I wanted so I found another approach. I put painters tape along the edges so that when I put the final coat of paint on the edges would be straight.

Paint Peeling

Well that didn’t work as I expected. The paint is peeling off in strips! What looked ok before, now looks like trash. Ugh.

No worries. I will try again.

Failure is proof that you tried. Now go try again..jpg

The chalk board paint is very thick – as is the deck stain. I theorize that the thickness of the paints plus the tape played some sort of factor in my peeling situation. To remedy that I will use spray paint instead ofΒ  a colored stain. The edges are taped in a straight line so there should not be any problems.

Well….It doesn’t look great, but I can totally visualize what it could look like with the chalkboard paint added on. I actually sprayed the silver paint last week but couldn’t decide if I wanted to paint the frame of the board or just keep it the natural blue color. Obviously I opted to paint it white for this project. Part of the reason I am choosing to paint it is to see if I will have the same peeling problems when they are painted next to each other like this.

KIMG3102

The dark one is actually red with blue painters tape on it – but the picture does not show it very well. You can see that I used tape to mark straight lines where I want to pain the chalk board. I am hopeful this approach will give me the clean lines I am looking for.

 

Moment of truth time. The shutters each have two coats of chalk board paint on them and have been dry for over 24 hours. I make sure to remove the tape slowly to prevent any of the paint from peeling off.

KIMG3118KIMG3120KIMG3121KIMG3119

Look! I found more ways that don’t work. Once again the paint is peeling off. At least this time most of the chalk board paint actually stayed on. Ugh. I don’t like it. BUT….I did learn that the color scheme looks good. Silver with white with black works nice. Also, I am able to compare how different the white is between the spray paint and the stain. They present completely differently. The spray paint is shiny and bright while the stain and matte and more of a cream color. #themoreyouknow

KIMG3123

Even the red shutter had some issues. Again, from afar, it looks pretty good. The videos below better demonstrate the issues with the chalk board paint peeling. The paint is very thick and because the plastic is not absorbent, the paint just sits on top and can be easily ripped off when the tape is removed.

 

What has me more frustrated than the chalk board paint peeling is that the spray paint peeled too. I thought for sure that because it was such a thin layer of paint that I would be fine. Nope. Also, I learned that the mist from the spray paint gets everywhere. That is to say, my stream of paint may be on one end of the shutter, but when the wind picks up small amounts of paint are spread everywhere. The best example is the center of the silver shutter. While the tape was still on the shutter the center of the shutter appeared silver. Not until the tape was removed did it become evident that my light mist of white paint actually significantly colored the center of the shutter.

Oooops.

 

So, I’m not sure how to proceed from here. An argument could be made that someone else may appreciate the ‘mistakes’ as creative quirks to the piece. The parts that I see as an ‘ooops’ may be the one-of-a-kind touch someone else is looking for.

What do you think? Should I try to sell it as is or scrap it completely?

What suggestions do you have to help me moving forward?

Thank you in advance for your feedback.

Never give up.jpg

Written by Sarah Palmer – Owner, Functional Rustic

Did you know Functional Rustic provides more than a blog – Check what others already know by shopping for Handmade Rustic DΓ©cor in the Functional Rustic Store.

 

Wooden Thank You Card ORANGE

Measures 3.5 in x 3.5 in x 5/8 in. The handmade Wooden Thank You Card by Functional Rustic is the unique thank you gift you didn’t know you were looking for until now. The Functional Rustic Wooden Thank You Card is small enough to fit in your pocket and durable enough to take with you wherever you go. PLUS, the Wooden Thank You Card is made from a salvaged wood shipping pallet and then hand painted with oil paints. Every single Wooden Thank You Card is unique making each card a truly one-of-a-kind expression of gratitude.

$10.00

 

Mini Chalk Board – Blue by Functional Rustic

The Mini Chalk Board by Functional Rustic is the fun and quirky handmade conversation piece you never knew you needed. The mini chalk board is made form repurposed pallet wood and hand painted with oil paint/chalkboard paint. Measurements: 19 in x 3.5 in x 5/8 in.

$15.00

Advertisements

One thought on “Learning How NOT to Repurpose a Shutter – Functional Rustic Approach

  1. […] I had high hopes of publishing a tutorial about how to repurpose a shutter into a Functionally Rustic Chalk Board today. Well….as is often the case with repurposing projects, things did not go as planned. Ha. You can read about my struggles Here. […]

Share Your Thoughts Here

This site uses Akismet to reduce spam. Learn how your comment data is processed.